Chevy 166 G-4500 Cutaway Van Type III Ambulance Conversion This document is the exclusive property of MEDIX Specialty Vehicles, Inc. and considered “on loan” to those to whom MEDIX has distributed it. © 2009 Chevy Metro Express 166 Type III Ambulance Conversion MEDIX Specialty Vehicles, Inc. is an experienced manufacturer of Chevrolet Ambulances. In 2001 MEDIX received Approval from General Motors and General Motors International Product Center to perform modifications to the Chevy Cutaway Van and continues to perform to the expectations of both General Motors and MEDIX customers.. We hope this “walk-around” of the Chevy Metro Express 166 Type III by MEDIX Specialty Vehicles, Inc. will assist you in making an informed choice about purchasing a Chevy 166. Chevy Metro Express 166 Type III Ambulance Conversion Chevy Metro Express 166 Type III Ambulance Conversion Chevy Metro Express 166 Type III Ambulance Conversion Chevy Metro Express 166 Type III Ambulance Conversion Overall Width 94” Overall Length 166” Overall Height 107” Wheel Base 159” Completed Vehicle Weight- 10,115 lbs. Usable Payload- 4,085 lbs. GVWR – 14,200 lbs. Front GAWR- 4,600 lbs. Rear- GAWR- 9,600 lbs. Chevy Metro Express 166 Type III Ambulance Conversion Interior Headroom 72” Floor Length 157+” Aisle Width 48.0” The Chassis TransmissionAutomatic 6-Speed Rear Axle Ratio- 3.73:1 EngineDuramax 6.6L V-8 Diesel Fuel Economy - 8-15 mpg The Chassis Batteries- Dual 770 CCA Total CCA- 1,540 In Roll-out tray in Curbside forward compartment The Chassis 225/75R16 E BSW Tires & Spare Shipped Loose Stainless Steel Wheel Liners w/ valve extensions- optional Tilt Steering Wheel; Power Windows, Door Locks & Mirrors; Dual Captain’s Chairs w/tilt back; AM/FM/CD Radio w/4-spkrs; molded rubber floor mats Fuel Fill w/cast aluminum bezel Environmental Systems HVAC Unit Output Vents & Filtered Return Air Located above Walk-Thru Fresh Air Intake Free-Blow HVAC System36K BTU Heat- 32K BTU Cool 720 CFM multi-speed fan, Thermostatic Control Powered Exhaust Vent Power Distribution & Control 20 Amp Shoreline Inlet Vented, latching, hinged door Located above Walk-Thru Common component circuit breakers and relays Electrical Cabinet Power Distribution & Control Front ConsoleSwitch Control Panel, Panel for Radios, Cup Holders, Siren Control Head. Map Book/Report Book Storage Slots optional Power Distribution & Control Switch Control Panel Digital Volt/Amp Meter Back lighted Legends Indicator Lamps Carson SA 500 Siren Control Head, multi-tone CPI Thru-the-Bumper Mounted Siren Speakers Power Distribution & Control Rear Action Area Rear Switch Control Panel w/HVAC thermostat control 12 VDC Outlet w/cover 125 VAC Duplex Outlets Emergency Lighting Emergency Lighting Whelen 4500 Halogen, 4-Red, 1-Clear center, 2- Clear rotators Whelen 9x7 Red Halogen Warning Lights on all side and rear corners Whelen 9x7 Amber Halogen Warning Light rear center Note: Optional 9 x 7 LED Lights replacing Light Bar shown Whelen 7x3 Red Halogen Warning Lights on fenders as Intersection Lights Whelen 5x2 LED Warning Lights as Grille Lights Whelen 9x7 Red Halogen Mid-Body Lights Patient Compartment Interior Space for the Patient, Space for the Medic Ten critically spaced dome lights; two folddown IV Hangers; Overhead grab rail Optional CPR Seat Configuration Easy, safe access to interior Optional CS Cabinet and Window over Squad Bench Patient Compartment Interior ALS Cabinet- Lower locking; Upper is open w/shelf or as Optional Configurations shown Aisle Width- 37” w/ Std ALS Cabinet Patient Compartment Interior Automotive style Technician’s Seat w/ Type II Lap and Shoulder belt NOTE: Type I Lap Belt Shown Steel Cabinet Base Storage w/drop-down latching door Shown with optional 125 VAC heater Patient Compartment Interior CPR Overhead Action Area Overhead Storage behind Tech SeatInverter Pre-Wire; Vacuum pump LifePak Area Inside/Outside Access Patient Compartment Interior Vacuum-Formed Cushions and Pads Lift-Up Sharps/Waste Shown with optional Cargo Net Patient Compartment Interior CPR Seat & Overhead Cabinet Action Area Overhead Primary Action Area 2nd Action Area, Storage Cabinet Patient Care Systems Vacuum Gauge hard plumbed to vacuum Pump; Aspirator Canister; dual quick-connect oxygen outlets (2-in Action Area, 1- over Squad Bench Exterior Compartment Access to Oxygen Cylinder Retention Bracket Shown with optional Zico Cylinder Retention Bracket Protective & Safety Surfaces •Aluminum Diamond Plate step body& upper threshold • LED Step Light •Stainless steel threshold w/safety grip tape •Stainless steel threshold w/safety grip tape •Aluminum grip strut, flip-up bumper step •Reflective tape on bumper edge Exterior Compartmentation - Streetside COMPT 2- Open Storage w/adjustable shelf Shown w/optional Spare Tire storage COMPT 1- Oxygen Storage; open storage Shown w/optional Zico Cylinder Retention Bracket COMPT 3- Inside/Outside access w/Adjustable shelf & open storage below Exterior Compartmentation - Curbside COMPT 5- Battery Storage w/Roll-Out Tray COMPT 4- ALS Cabinet- Inside /Outside access COMPT 6- Back Board Storage w/Adjustable belts Shown w/ optional divider Paint, Decals, Lettering Paint Stripe- Optional Star-of-Life Decals- Optional Lettering- Optional Warranties Structural Warranty- 180 Months (15 yrs) Electrical Warranty- 72 Months/72,000 Miles Limited Warranty- 12 Months/12,000 Miles Paint - 48 Months Contact MEDIX 3008 Mobile Drive Elkhart, IN 46514 U.S.A. Ph- 574.266.0911 Fx- 574.266.6669 [email protected] [email protected] www.medixambulance.com MEDIX Specialty Vehicles, Inc. 3008 Mobile Drive Elkhart, Indiana 46514 U.S.A. PH- 574.266.0911 FX- 574.266.6669 www.medixambulance.com Due to on-going product improvements and changing requirements of the ambulance industry, Medix Specialty Vehicles Inc. reserves the right to change this specification and related product without prior notice and without obligation to change prior product or parts.